摆动下液体分布器流体分布的数值模拟研究

doi:10.3969/j.issn.1006-8805.2021.04.003

Petro-chemical Equipment Technology ›› 2021, Vol. 42 ›› Issue (4): 11-14.doi: 10.3969/j.issn.1006-8805.2021.04.003

• STATIC EQUIPMENT • Previous Articles Next Articles

Numerical Simulation Research on Fluid Distribution of Liquid Distributor under Sway

Zhou Guijuan¹, Guo Zhifang², Nie Ao¹, Chen Jianjuan¹, Sun Xijin¹

1. SINOPEC Engineering Incorporation, Beijing, 100101;
2. Offshore Oil Engineering Co., Ltd., Tianjin, 300451

Accepted:2021-06-25 Online:2021-07-14 Published:2021-07-14

Abstract

Abstract: In this paper, computational fluid dynamics is adopted to simulate the flow field in the liquid distributor. The mass flow distribution and pressure drop at the outlet of the distributor in the horizontal and sway states were studied. The results show that after adding the sway at a certain angle, the deviation of the flow distribution increases from 6.75% to 21.24%. The nonuniformity of the outlet flow is increased significantly. Besides, sway in different directions has the same influence on the uneven distribution of flow. Increasing the height of the distributor inlet properly or optimizing the flow rate under the sway state can improve the uniformity of the liquid distribution of the liquid distributor under sway. The research results can provide data support for the structure optimization of the distributor under sway.

Key words: liquid distributor, sway, numerical simulation

Zhou Guijuan, Guo Zhifang, Nie Ao, Chen Jianjuan, Sun Xijin. Numerical Simulation Research on Fluid Distribution of Liquid Distributor under Sway[J].Petro-chemical Equipment Technology, 2021, 42(4): 11-14.

[1]	Ma Fengbo. Analysis on the Influence of Blade Wrap Angle on Flow Field and Hydraulic Vibration of Medium-high Specific Speed Pump [J]. Petro-chemical Equipment Technology, 2021, 42(3): 33-35,40.
[2]	Liu Longlong, Qi Binbin, Guo Hongbiao Li Xue. The Influence of Blade Front Clearance on the Performance of Compressors [J]. Petro-chemical Equipment Technology, 2021, 42(2): 35-39.
[3]	Wang Kun, Zhu Liyun, Li Anjun, Wang Zhenbo, Wang Guotao. Numerical Simulation of Particle Flow Characteristics in Turbulent Fluidized Bed [J]. Petro-chemical Equipment Technology, 2021, 42(1): 5-10.
[4]	Nie Ao. Numerical Simulation of Vane Gas-Liquid Separator [J]. Petrochemical Design, 2021, 38(1): 28-32.
[5]	Zhang Yangle. Study on Numerical Simulation of Flow Field in the Plate of Plate-shell Heat Exchanger [J]. Petro-chemical Equipment Technology, 2020, 41(5): 5-10.
[6]	Nie Yiqiang. Theoretical Analysis and Numerical Simulation of the Effects of Axial Heat Conduction on the Wall Temperature of Heat Exchange Tubes and Shell Cylinder [J]. Petro-chemical Equipment Technology, 2020, 41(4): 1-7.
[7]	Zhao Yong. Study on Structure Optimization of Different Cyclones in CFB Boiler [J]. Petro-chemical Equipment Technology, 2020, 41(4): 8-14.
[8]	Chen Chao, Zhang Guijun. Introduction, Analysis and Numerical Simulation of Axial Self-balancing Magnetic Pump [J]. Petro-chemical Equipment Technology, 2020, 41(1): 16-18.
[9]	Zhang Hexiang. Development of New-type Reforming Furnace Based on Numerical Simulation [J]. Petro-chemical Equipment Technology, 2019, 40(5): 21-24.
[10]	Zhao Yongtao, Zhao Xingyou, Lin Yuming. NUMERICAL SIMULATION AND EXPERIMENTAL VERIFICATION RESEARCH OF WALL PLATE STRAIN CAUSED BY UNEVEN SETTLEMENT OF STORAGE TANK FOUNDATION[17] [J]. Petrochemical Safety Technology, 2019, 35(3): 17-21.
[11]	Zhou Guijuan, Xu Jing. Numerical Simulation of Flow and Combustion Process in Claus Reaction Furnace[1] [J]. Petrochemical Design, 2019, 36(2): 1-3.
[12]	Tian Wenshuang;Sun Weiguo(CNOOC Energy Conservation and Emission Reduction Monitoring Center,Tianjin,300452;Assystem Germany GmbH,Munich,Germany,80331-81929). NUMERICAL SIMULATION ON SPINNING FORMING PROCESS OF ELLIPSOIDAL HEAD [J]. Petro-Chemical Equipment Technology, 2019, 40(1): 14-18.
[13]	. STUDY ON THE NUMERICAL SIMULATION OF FLOW FIELD IN TUBE SIDE OF TWISTED TUBE HEAT EXCHANGER WITH DIFFERENT TORQUES [J]. Petro-Chemical Equipment Technology, 2016, 37(3): 13-16.

Numerical Simulation Research on Fluid Distribution of Liquid Distributor under Sway

Like

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 13

Metrics

Comments

Recommended 0